ppt on partial replacement of cement with glass powder

1) Determine the effect of glass powder on concrete with the replacement of combination of coarse and fine aggregate. 2) Replacement of cement with glass powder in different water cement ratio. 3) In the present study the ordinary Portland cement was used. Further its mechanical properties can be compared by using different cement.

Read More

Petroleum coke, or petcoke, is a product produced from all types of oil (light/heavy crudes) during the oil refining process. Many different products are extracted from a barrel of crude oil in addition to gasoline, diesel and jet fuels.

Read More

Dec 01, 2020· For this purpose, waste glass powder (GP) has been used as a partial replacement with cement in addition to study the effect of sulphate solution consternation on its mechanical properties. 2. Research significance. Sulphate attack often takes decades to develop. As a result, few studies have examined concretes after long exposure periods.

Read More

Jan 30, 2017· Soliman and Tagnit-Hamou replaced cement with fine glass powder (with a particle size less than 30 μm) in high-strength concrete (containing PC based SP admixture) at a replacement ratio from 10% to 50%, by increments of 10% and reported that the air content was increased by 0%, 10.52%, 7.89%, 10.53%, and 23.68%, respectively . The high ...

Read More

Flow and compressive strength tests on mortar and concrete were carried out by adding 0–25% ground glass in which water to binder (cement + glass) ratio is kept the same for all replacement levels.

Read More

Jun 01, 2017· The glass powder replacement in cement was varied (0–25%). Mix proportion of concrete is shown in Table 6. Firstly, stone chips and sand were dry mixed for a minute. Appropriate quantity of glass powder was blended with cement in a separate container and then incorporated into the aggregate matrix (mixed earlier).

Read More

Replacement of Cement in Concrete P. Vipul Naidu1 and Pawan Kumar Pandey2 1Civil-SOT, Pandit Deendayal Petroleum University, Raysan, Gandhinagar, INDIA. 2Engineer, DMRC, Sector-18, Rohini, New Delhi, INDIA. Abstract Cement is a binding material, a substance that sets and hardens independently, and can bind other materials together.

Read More

Jan 28, 2016· In this experiment we use waste glass powder as a partial replacement of cement and a comparative study has been made with other admixture such as fly ash and silica fume. A series of test were conducted with partial replacement of glass by 15% and 30% to weight of cement where as we have used only 15% of partial replacement in case of fly ash ...

Read More

Glass ionomer cements are the mixture of glass and an organic acid. Initially, glass ionomers were used to replace the lost osseous; but now, these are used in dentistry because of their tooth-colored resemblance and translucency. Glass ionomer cement does not require any binding agent when placed in cavities [110 ].

Read More

PARTIAL REPLACEMENT OF CEMENT WITH MARBLE DUST POWDER Prof. P.A. Shirule a*, Ataur Rahman b, Rakesh D. Gupta c Address for Correspondence a*bc Dept. Of Civil Engineering, SSBT's COET, Bambhori, Jalgaon, Maharashtra – 425001 ABSTRACT Leaving the waste materials to the environment directly can cause environmental problem.

Read More

ash and glass powder can be used in the partial replacement of cement in concrete production. OBJECTIVE OF THE STUDY To investigate the best mix proportion for the partial replacement of sugarcane bagasse ash and glass powder for cement by the different strength values obtained for different sample specimens. IJTSRD33538

Read More

Lec 2a - Volumetric Properties.ppt. De La Salle University. ... PARTIAL_REPLACEMENT_OF_CEMENT_WITH_GLASS.pdf. glass powder; 51 pages. PARTIAL_REPLACEMENT_OF_CEMENT_WITH_GLASS.pdf. Technological University of the Philippines Manila. EE PS. Lecture (Chapter 3).pdf. Monash University. CHE 3161.

Read More

Jul 18, 2019· Posted on July 18, 2019. Concrete is a mixture of cement, gravel, sand, water and a range of aggregates. With about 10 billion tons of concrete produced every year, it is the most consumed substance in the world, second only to water.. It is also the world's most widely used material for construction – from bridges to large buildings, concrete forms the very foundation of our …

Read More

Experimental programme was conducted using 30%, 40%, 50%, 60% and 70% partial replacement of fine aggregate with stone dust has been taken for concrete of M25 grade with 0.46 water cement ratio.

Read More

In this study, finely powdered waste glasses are used as a partial replacement of cement in concrete and compared it with conventional concrete. This work examines the possibility of using Glass powder as a partial replacement of cement for new concrete. Glass powder was partially replaced as 10%, 20%, 30 % and 40 % and tested for its ...

Read More

Then found result Conventional concrete shows a 3 days compressive strength as 9 N/mm and 2.5% replacement of glass powder in cement increased the compressive strength by 37% in 3 days.10% replacement of glass 8 powder increment increased the compressive strength by 52.6% in 3 days.15% replacement of glass powder in cement increased the ...

Read More

Bharath V B | Kuldeep Singh Solanki | Abdirizak Ismail Jimale "An Experimental Study on Properties of Concrete by Partial Replacement of Cement with Sugarcane Bagasse Ash and Glass Powder" Published in International Journal of Trend in Scientific Research and Development (ijtsrd), ISSN: 2456-6470, Volume-4 | Issue-6, October 2020, pp.868-872 ...

Read More

for each 1:1.80:3.84 concrete mix with partial replacement of cement with a w/c ratio as 0.52 were also cast. After about 24 h the specimens were de-moulded and water curing was continued till the respective specimens were tested after 7, 14 and 28 days for compressive strength test. Compressive strength

Read More

As with mortar, concrete cube samples were prepared and tested for strength (until 1 year curing). The compressive strength test results indicated that recycled glass mortar and concrete gave better strength compared to control samples. A 20% replacement of cement with waste glass was found convincing considering cost and the environment.

Read More

Dec 01, 2017· Here, 6 mix plans varies in RHA proportions by about 0–25% also a control mix prepared to. Although there is a significant number of a study focused on application and workability of partial replacement of mineral additions in concrete, the present study aimed to present an analysis based on benefits resulting from different contents of RHA.

Read More

A STUDY ON USAGE OF WASTE IN CONCRETE WITH PARTIAL REPLACEMENT OF COARSE AGGREGATE BY CHOPPED SCRAP TYRE AND FINE AGGREGATE BY CRUSHED CERAMIC TILE P. MANOJ 1, S.V.SATYANARAYANA 2 1M. Tech scholar, Dept. of Civil, R V R & J C College of engineering, Guntur, A.P 2Assistant Professor, Dept. of Civil, R V R & J C College of engineering, …

Read More

The high cost of construction materials like cement and reinforcement bars, has led to increased cost of construction. This, coupled with the pollution associated with cement production, has necessitated a search for an alternative binder which can be used sorely or in partial replacement of cement in concrete production.

Read More

most extreme quality of cement happens at around 10% glass powder. The quality of cement lessens past 10% glass powder Vikram Pre Dr. G. Vijayakumar et al (2013) considered that finely powdered waste glasses are utilized as a partial substitute of bond in concrete and contrasted it and conventional cement.

Read More

Apr 05, 2015· The partial replacement of glass powder as fine aggregate Makes the concrete strengthen. Thus our project states that concrete can be strengthen by glass powder replacement, which makes the waste in to useful, so the waste materials …

Read More

May 30, 2018· The effect of GGBS and fly ash as partial cement replacement was examined on concrete cubes, cylinder and beams. In this research paper we have kept percentage of fly ash for every trial constant except for conventional trial and GGBS was used to replace cement partially from 40% up to 70% while keeping fly ash 25% as constant throughout.

Read More

Glass Powder ‟ as a partial replacement of cement to assess the pozzolanic nature of fine glass powder when mixed in concrete and compare the performance when other pozzolanic materials are mixed. The present study shows that waste glass, if ground finer than One ton of carbon dioxide is released into the atmosphere for

Read More

Dec 31, 2020· Abstract. In this paper, a comprehensive experimental investigation was conducted into the effect of the particle size distributions (PSDs) and percentages of waste powdered glass as a partial replacement of cement on the long-term mechanical behavior of concrete produced at two different cement …

Read More

as partial replacement for aggregates in M25 grade of concrete mix at different percentages and its effect on ... aggregates and waste tyre crumb powder replaced to cement at 5%, 7.5% and 10% to examine the concrete properties. ... WEIGHT OF CEMENT FOR 1 M3 CONCRETE. Percentage of Glass fiber . Glass fiber (kg/m. 3) Cement (kg/m. 3) 0.4% . 1 ...

Read More